반응 #1178405

반응 방정식

(Z)-4-oxo-5-azaundec-2-enedioic acid

acetic anhydride

phenothiazine

HCl

water

→

desired product

N-Succinimidyl 6-Maleimidohexanoate

용매

THF

Triethylamine

반응 조건

후처리

1. 1
   기타equipped with an overhead stirrer
2. 2
   온도the mixture was heated
3. 3
   온도to reflux
4. 4
   온도After a total of 4 hours of reflux
5. 5
   workup.STIRRINGThe mixture was stirred 3 hours at room temperature
6. 6
   여과was filtered through a filtration pad (Celite 545, J. T. Baker, Jackson, Tenn.)
7. 7
   기타to remove solids
8. 8
   추출The filtrate was extracted with 4×500 ml of chloroform
9. 9
   건조the combined extracts were dried over sodium sulfate
10. 10
    workup.ADDITIONAfter adding 15 mg of phenothiazine
11. 11
    기타polymerization
12. 12
    기타the solvent was removed under reduced pressure
13. 13
    기타The 6-maleimidohexanoic acid was recrystallized from 2:1 hexane
14. 14
    기타chloroform to give typical
15. 15
    기타yields of 76-83 g (55-60%) with a melting point of 81-85° C

실험 절차

(Z)-4-oxo-5-azaundec-2-enedioic acid, 150.0 g (0.654 moles), acetic anhydride, 68 ml (73.5 g, 0.721 moles), and phenothiazine, 500 mg, were added to a 2 liter three-neck round bottom flask equipped with an overhead stirrer. Triethylamine, 91 ml (0.653 moles), and 600 ml of THF were added and the mixture was heated to reflux while stirring. After a total of 4 hours of reflux, the dark mixture was cooled to about 60° C. and poured into a solution of 250 ml of 12 N HCl in 3 liters of water. The mixture was stirred 3 hours at room temperature and then was filtered through a filtration pad (Celite 545, J. T. Baker, Jackson, Tenn.) to remove solids. The filtrate was extracted with 4×500 ml of chloroform and the combined extracts were dried over sodium sulfate. After adding 15 mg of phenothiazine to prevent polymerization, the solvent was removed under reduced pressure. The 6-maleimidohexanoic acid was recrystallized from 2:1 hexane:chloroform to give typical yields of 76-83 g (55-60%) with a melting point of 81-85° C. Analysis on a NMR spectrometer was consistent with the desired product: 1H NMR (CDCl3) maleimide protons 6.55 (s, 2H), methylene adjacent to nitrogen 3.40 (t, 2H), methylene adjacent to carbonyl 2.30 (t, 2H), and remaining methylenes 1.05-1.85 (m, 6H).

출처